ITEM # WCD01
115v. Corona Discharge Unit

To be used in place of/superior to UV lamp (pictured right) for ozonator.

IN STOCK, READY TO SHIP!




Advantages of Corona Discharge ozone generation

•Corona discharge ozone generators can use oxygen preparation thereby doubling the ozone output per given volume vs. dry air
•Small construction allowing generator to be installed in virtually any area
•Creates a more pure form of ozone without creating other harmful or irritating gases
•Corona cell life can exceed two years
•Can create high quantities of ozone (up to 100-lbs/day)
•Can be more cost-effective than UV-ozone generation

Ultraviolet (UV) ozone generation

Ultraviolet lamps have been used for decades to generate ozone. This lamp emits UV light at 185
nanometers (nm). Light is measured on a scale called an electromagnetic spectrum and its increments are referred to as nanometers.

Disadvantages of UV ozone generation

•Maximum ozone production rate is two grams/hr per UV bulb - depending on size
•Highest concentration of ozone that can be produced by 185-nm UV lamp is 0.2 percent by weight, approximately 10% of the average concentration available by corona discharge
•Considerable more electrical energy is required to produce a given quantity of ozone by UV radiation than by corona discharge
•Lower gas phase concentrations of ozone generated by UV radiation translate into the handling of much higher gas volumes than with CD-generated ozone
•UV lamps solarize over time, requiring periodic replacement

Installation Instructions

Many do-it-yourself homeowners customarily perform small electrical repair jobs around their home. Although this kind of work is not for everyone, with the proper training and knowledge there are a number of electrical repairs that can be considered to be safely within the realm of the average homeowner. However, there are also some electrical jobs and repairs that should never be attempted by homeowners. In the case of replacing the UV lamp with Corona discharge it is recommended this work be performed by a qualified licensed electrician.

This unit requires removing the Ballast (power supply) and lamp and then replacing it with the CD Unit.

Each unit uses the same hose from the air pump. We include new hose in each unit.

ITEM# WT102
120v. ozone air pump for ozone lamp pictured above.
MSRP: $240

IN STOCK, READY TO SHIP!

ITEM# WT103
220v. ozone air pump for ozone lamp pictured above.
MSRP:

IN STOCK, READY TO SHIP!